555-2007

2mm LED CBI® Circuit Board Indicator Single PART NO. 2.54 [.100 max] 1.14 [.045] 5.08 [.200] 555-2xxx COLOR Red Green Yellow Red, 5V Red, 5V Red, 24V Red, 5V Green, 5V Yellow, 5V GENERAL PURPOSE 555-2001 555-2301 555-2401 555-2003 555-2007 555-2008 555-2009 555-2303 555-2403 6.35 [.250] 3.18 [.125] 2.03 [.080] INTEGRAL RESISTOR, VARIOUS VOLTAGES + 3.68 [.145] 2.54 [.100] CATHODE .254 [.010] 0.965 ±.05 [.038 ±.002] 1.02 [.040] RECOMMENDED P.C. HOLE PATTERN .686 MAX [.027] 2.54 [.100] Dimensions in mm [inches] Features • Multiple CBIs form horizontal LED arrays on 2.54mm (0.100”) center-lines • High Contrast, UL 94 V-0 rated, black housing • • • • • • Oxygen index: 31.5% Polymer content: PBT, 0.079 g Housing stand-offs facilitate PCB cleaning Solderability per MIL-STD-202F, method 208F LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 Compatible with: 555-4xxx Quad Block Tolerance note: As noted, otherwise: • LED Protrusion: ±0.04 mm [±0.016] • CBI Housing: ±0.02mm[±0.008] 3-4 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 555-2xxx Typical Operating Characteristics (TA = 25°C) GENERAL PURPOSE Peak Wavelength nm 650 565 583 IV mcd 1.2 1 2 See LED data sheet for additional information See Page 3-17 and 3-18 for Reference Only LED Drive Circuit Examples See Page 3-19 for Pin Out Part Number 555-2001 555-2301 555-2401 Color Red Green Yellow VF Volts 1.6 2.4 2.2 Test Current (mA) 20 20 20 Viewing Angle 2 Θ1/2 40° 40° 40° LED Data sheet 2ND-9412 2ND-9414 2ND-9416 Page # 3-14 3-14 3-14 INTEGRAL RESISTOR, VARIOUS VOLTAGES Part Number 555-2003 555-2007 555-2008 555-2009 555-2303 555-2403 Color Red Red Red Red Green Yellow Peak Wavelength nm 650 650 650 650 565 583 IV mcd 1.9 .9 .9 .6 2.5 2.1 IF mA 6 3 3 1 4.7 4.7 Test Voltage 5 5 24 5 5 5 Viewing Angle 2 Θ1/2 40° 40° 40° 40° 40° 40° LED Data sheet 2RD-9614 2RD-9613 2RD-9623 2RD-9618 2RD-9615 2RD-9616 Page # 3-15 3-15 3-16 3-15 3-15 3-15 3 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 3-5 2mm General Purpose Diffused TYPE 2ND-9412* 2ND-9414* 2ND-9416* 2ND-xxxx COLOR Red Green Yellow * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red Green Yellow ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Derating (mW/°C) From 25°C Forward Current (mA) Peak Current (mA) Pulse width = 1 µs -9412 80 1.1 40 250 -55/+100 -55/+100 -9414 80 1.1 25 250 -55/+100 -55/+100 -9416 80 1.1 25 250 -55/+100 -55/+100 Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Red Green Yellow OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) IF=20mA Peak Wavelength (nm) λ Peak Viewing Angle (2 Θ1/2) Forward Voltage (V) IF=20mA Reverse Voltage (V), IR=10µA 1 -9412 Min. Typical Typical Typical Typical Max. Min. 1 1.2 650 40° 1.6 2 3 -9414 .5 1 565 40° 2.4 3 3 -9416 .6 2 583 40° 2.2 3 3 Θ ¼2is the off axis angle at which the luminous intensity is half the axial luminous intensity 3-14 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 2mm Integral Resistor, 5 Volts Diffused 2RD-9613 thru 2RD-9618 TYPE 2RD-9613* 2RD-9614* 2RD-9615* 2RD-9616* 2RD-9618* COLOR Red Red Green Yellow Red * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. 3 Red Red Green Yellow Red ABSOLUTE MAXIMUM RATINGS (TA=25°C) Forward Voltage (V) Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature -9613 6 -55/+100 -55/+100 -9614 6 -55/+100 -55/+100 -9615 6 -55/+100 -55/+100 -9616 6 -55/+100 -55/+100 -9618 6 -55/+100 -55/+100 260°C, 5 seconds, 1.6 mm from case Red Red Green Yellow Red OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) VF=5V Peak Wavelength (nm) λ Peak Viewing Angle (2 Θ1/2) Forward Current (mA) VF=5V Reverse Voltage (V), IR=100µA Min. Typical Typical Typical Typical Max. Min. - 9613 .4 .9 650 40° 3 4 6 -9614 .8 1.9 650 40° 6 8 6 -9615 .8 2.5 565 40° 4.7 6.7 6 -9616 1.3 2.1 583 40° 4.7 6.7 6 -9618 .3 .6 650 40° 1 2.6 6 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 3-15 2mm Integral Resistor, Various Voltages Diffused 2RD-9619 thru 2RD-9623 COLOR Red, 14V Red, 3.6V Red, 10V Red, 15V Red, 24V * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. TYPE 2RD-9619* 2RD-9620* 2RD-9621* 2RD-9622* 2RD-9623* Red 14V Red 3.6V Red 10V Red 15V Red 24V ABSOLUTE MAXIMUM RATINGS (TA=25°C) Forward Voltage (V) Operating Temperature (°C) Storage Temperature (°C) Soldering Temperature -9619 14 -55/+100 -55/+100 -9620 3.6 -55/+100 -55/+100 -9621 10 -55/+100 -55/+100 -9622 15 -55/+100 -55/+100 -9623 24 -55/+100 -55/+100 260°C, 5 seconds, 1.6 mm from case Red 14V Red 3.6V Red 10V Red 15V Red 24V OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) VF=Forward Voltage Peak Wavelength (nm) λ Peak Viewing Angle (2Θ1/2) Forward Current (mA) VF=Forward Voltage Reverse Voltage (V), IR=100µA Min. Typical Typical Typical Typical Max. Typical -9619 1.3 3.1 650 40° 10 15 15 -9620 2.6 6.2 650 40° 20 25 4.6 -9621 1.8 4.2 650 40° 14 18 11 -9622 .3 .9 650 40° 3 3.8 16 -9623 .4 .9 650 40° 3 3.8 25 3-16 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com