STEVAL-ISS001V1

STEVAL-ISS001V1 Line interactive 450 W UPS reference design - 120 V / 60 Hz model Data Brief Features ■ Output rating power: 700 VA / 450 W ■ Input voltage: 83 Vac ± 3% - 153 Vac ± 3% ■ Input frequency: 60 Hz ■ Output voltage: 96 - 138 Vac ± 3 Vac ■ Output frequency: 60 Hz ± 0.1 Hz ■ On battery output waveform: quasi-sine (square wave) ■ Transfer time: Class 3 [EN62040-3] ■ Typical recharge time: 8h ■ Backup time (full load): 2.5 - 3 min. ■ Battery quantity: 2 pieces ■ Battery nominal voltage: 12 V ■ Battery capacity: 7.2 Ah ■ Battery recharge: two steps ■ Operating temperature: 0 °C to + 40 °C ■ Storage temperature: - 20 °C to + 60 °C ■ Size (H x W x D): 175 mm x 120 mm x 430 mm ■ Weight: 11 kg ■ Shipping weight: 11.5 kg ■ EMI classification: EN 62040-2 STEVAL-ISS001V1 The UPS was designed with RS-232 joint signal and USB interfaces (USB for RS-232 converter). It is possible to connect the UPS to a PC using an RS-232 or USB cable and control the UPS status through the "UPS Monitor 3.0x" software that must be installed on the same PC. Description This UPS reference design was built employing off-line topology with AVR boost and buck regulation of the mains. The inverter module contains the push-pull DC-DC converter and the DC-AC output full bridge generating a quasi-sine waveform. A microcontroller controls all UPS functions. It monitors the mains parameters (input/output mains voltage and phase, output inverter voltage, battery voltage, output current and output power) in order to ensure the proper level of the output voltage. April 2008 Rev 1 For further information contact your local STMicroelectronics sales office. 1/4 www.st.com 4 Board schematic 1 STEVAL-ISS001V1 Board schematic Figure 1. Schematic D C B RFIEMI12st05v031.sch 1 RXD RXD INP_LEV VCC VCC VCC VDD VDD PHASE PHASE AC_IN2 AC_IN1 AC_IN1 AC_IN2 Input Voltage & Phase Measurement BUTTON INP_LEV INP_LEV AC_IN1 AC_IN2 PHASE InputVoltage12st05v031.sch ACI! ACI! ACF ACF ACF ACL! ACL! ACH! ACH! ACH! OUT_REL! OUT_REL! OUT_REL! OUT_LEV OUT_LEV ACL! INV_A INV_B INV_B HVDC VDD VDD INV_OUT1 GND AC/DC Charger ACDC12st05v031.sch GND CHOFF VDD AC_1 AC_2 VDD +VOUT AC_1 AC_1 AC_2 AC_2 VDD +VOUT +VOUT VDD VBAT AKK_LEV Power Supply VBAT GND VCC Battery Voltage VCCPU VCCPU VCC VCC AC_IN1 AC_IN1 AC_IN1 AC_IN2 AC_IN2 AC_IN2 GND VCC AKK_LEV INV_OUT2 VBAT VBAT VCCPU VCC GND VCC AKK_LEV GND Protection BatteryVoltage12st05v031.sch AC_2 INV_OUT1 VDD GND VAKK BatOver12st05v031.sch GND Battery Overcurrent GND BATTERY VBAT AC_1 AC_2 DC/AC Invverter HVDC VAKK CHOFF CHOFF VDD AC_1 AC_2 INV_OUT2 VDD GND GND HVDC INV_A INV_B SHD VAKK SHD AC_1 DCAC12st05v031.sch VDD VDCDC OUT_LEV DC/DC converter DCDC12st05v031.sch VDCDC GND AVR TRAFO INV_A SHD Output Voltage Inverter InverterVoltage12st05v031.sch GND Microcontroller12st05v031.sch ACI! VDCDC Power Relays RXD AC_IN2 TXD GND TXD AC_IN1 USB_IN! TXD Relays12st05v031.sch GND USB_IN! UPS_OFF! AC_IN1 AC_IN2 ACF1! UPS_OFF! EMI/RFI FILTER AC_IN2 FUSE AC_IN1 ACF1! INPUT USB_IN! BAT_LOW ACF! Inerface unit ACF! ACF1! UPS_OFF! GND BAT_LOW ACF! Interface12st05v031.sch GND BAT_LOW VCC GND LED INDICATIONS Microcontroller unit VCC VCC GND FUSE GND VPP VPP ON/OFF ON/OFF ON/OFF SW_ONP SW_ONP SW_ONP PowerSupply12st05v031.sch VCC IOUT_1 PWR_LEV PWR_LEV IOUT_1 IOUT_1 IOUT_2 IOUT_2 PWR_LEV IOUT_2 GND GND GND Output Current Measurement OutputCurrent12st05v031.sch GND 8 OUTPUT D C B 2/4 STEVAL-ISS001V1 2 Revision history Revision history Table 1. Document revision history Date Revision 14-Apr-2008 1 Changes Initial release. 3/4 STEVAL-ISS001V1 Please Read Carefully: Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any time, without notice. All ST products are sold pursuant to ST’s terms and conditions of sale. Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no liability whatsoever relating to the choice, selection or use of the ST products and services described herein. No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such third party products or services or any intellectual property contained therein. UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT. UNLESS EXPRESSLY APPROVED IN WRITING BY AN AUTHORIZED ST REPRESENTATIVE, ST PRODUCTS ARE NOT RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONAL INJURY, DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK. Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any liability of ST. ST and the ST logo are trademarks or registered trademarks of ST in various countries. Information in this document supersedes and replaces all information previously supplied. The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners. © 2008 STMicroelectronics - All rights reserved STMicroelectronics group of companies Australia - Belgium - Brazil - Canada - China - Czech Republic - Finland - France - Germany - Hong Kong - India - Israel - Italy - Japan Malaysia - Malta - Morocco - Singapore - Spain - Sweden - Switzerland - United Kingdom - United States of America www.st.com 4/4